CDL Practice Tests: Hazardous Materials (hazmat) Endorsement

Choose A Section:

Go!
Question #392 (1 of 10)

Give a brief explanation of the problem:

Optional: Leave your email address if you would like a reply:

Report Cancel

Describe the proper placement of placards on the vehicle:

  • A placarded vehicle must have at least four identical placards. Two go on the front, two go on the rear of the vehicle. Placards must be readable from the front and rear.
  • A placarded vehicle must have at least four identical placards. They are put on the front, rear, and both sides of the vehicle. Placards must be readable from all four directions.
  • A placarded vehicle must have at least eight identical placards. They are put on the front, rear, and both sides of the vehicle. Placards must be readable from all four directions.
  • A placarded vehicle must have at least two identical placards. They are put on the front and rear of the vehicle. Placards must be readable from the front and rear of the vehicle.
A placarded vehicle must have at least four identical placards. They are put on the front, rear, and both sides of the vehicle. Placards must be readable from all four directions.
Previous Next
Question #441 (2 of 10)

Give a brief explanation of the problem:

Optional: Leave your email address if you would like a reply:

Report Cancel

Which of the following is the INCORRECT driver response to a hazardous material crash or incident?

  • Remain in the vehicle and keep the engine running
  • Communicate the danger of the hazardous materials to emergency response personnel
  • Provide emergency responders with the shipping papers and emergency response information
  • Keep people away from the scene

As a professional driver, your job at the scene of a crash or an incident is to:

  • Keep people away from the scene.
  • Limit the spread of material, only if you can safely do so.
  • Communicate the danger of the hazardous materials to emergency response personnel.
  • Provide emergency responders with the shipping papers and emergency response information.
Previous Next
Question #425 (3 of 10)

Give a brief explanation of the problem:

Optional: Leave your email address if you would like a reply:

Report Cancel

Never park with Division 1.1, 1.2 or 1.3 explosives within 5 feet of the traveled part of the road. Also, except for short periods of time needed for vehicle operation necessities (e.g., fueling), do not park within 300 feet of:

  • A bridge, tunnel or building.
  • A place where people gather.
  • An open fire.

  • A bridge, tunnel or building
  • All these are correct
  • An open fire
  • A place where people gather.

Never park with Division 1.1, 1.2 or 1.3 explosives within 5 feet of the traveled part of the road. Except for short periods of time needed for vehicle operation necessities (e.g., fueling), do not park within 300 feet of:

  • A bridge, tunnel or building.
  • A place where people gather.
  • An open fire.
Previous Next
Question #381 (4 of 10)

Give a brief explanation of the problem:

Optional: Leave your email address if you would like a reply:

Report Cancel

When transporting hazardous materials, whose responsibility is it to package, mark and label the materials; prepare shipping papers; provide emergency response information; and supply placards?

  • The shipper
  • The driver
  • The carrier
  • Hazmat regulators

9.2.1 – The Shipper

Packages, marks and labels the materials; prepares shipping papers; provides emergency response information; and supplies placards.

Previous Next
Question #412 (5 of 10)

Give a brief explanation of the problem:

Optional: Leave your email address if you would like a reply:

Report Cancel

Which of the following is true regarding bulk packaging for hazardous materials?

  • Certain bulk packages only have to be placarded on the two opposite sides or may display labels. All other bulk packages must be placarded on all four sides
  • A bulk package and a vehicle transporting a bulk package must be placarded, even if it only has the residue of a hazardous material
  • All these are true
  • Bulk packaging is a single container with a capacity of 119 gallons or more
Bulk packaging is a single container with a capacity of 119 gallons or more. A bulk package and a vehicle transporting a bulk package must be placarded, even if it only has the residue of a hazardous material. Certain bulk packages only have to be placarded on the two opposite sides or may display labels. All other bulk packages must be placarded on all four sides.
Previous Next
Question #432 (6 of 10)

Give a brief explanation of the problem:

Optional: Leave your email address if you would like a reply:

Report Cancel

The power unit of placarded vehicles must have a fire extinguisher with a UL rating of 10:

  • 10 A:B or more
  • 5 B:C or more
  • 10 B:C or more
  • 10 A:C or more

The power unit of placarded vehicles must have a fire extinguisher with a UL rating of 10 B:C or more.

Previous Next
Question #403 (7 of 10)

Give a brief explanation of the problem:

Optional: Leave your email address if you would like a reply:

Report Cancel

Hazardous materials shipping papers must include detailed information about the product, but what else must be included and is the responsibility of the shipper?

  • The emergency response telephone number
  • The location of the nearest emergency response facility
  • The federal hazmat approval number
  • The restricted cargo declaration number
Shipping papers also must list an emergency response telephone number. The emergency response telephone number is the responsibility of the shipper. It can be used by emergency responders to obtain information about any hazardous materials involved in a spill or fire.
Hopefully, you will never use it, but make sure you know who to call in case of a spill or accident
Previous Next
Question #406 (8 of 10)

Give a brief explanation of the problem:

Optional: Leave your email address if you would like a reply:

Report Cancel

How can you identify whether or not a shipment may contain hazardous materials?

  • An entry on the shipping papers with a proper shipping name, hazard class and identification number?
  • All these are indications of hazardous materials
  • A highlighted entry or one with an “X” or “RQ” on the shipping papers in the hazardous materials column?
  • Is a hazard class label, proper shipping name, or identification number on any of the packages?

Learn to recognize shipments of hazardous materials. To find out if the shipment includes hazardous materials, look at the shipping paper. Does it have:

  • An entry with a proper shipping name, hazard class and identification number?
  • A highlighted entry or one with an “X” or “RQ” in the hazardous materials column?

Is a hazard class label, proper shipping name or identification number on the package?

Previous Next
Question #384 (9 of 10)

Give a brief explanation of the problem:

Optional: Leave your email address if you would like a reply:

Report Cancel

When transporting hazardous materials, whose responsibility is it to make sure the shipper has identified, marked, and labeled the hazardous materials properly and to refuse leaking packages and shipments.

  • The driver
  • Hazmat regulators
  • The carrier
  • The shipper

9.2.3 - The Driver

  • Makes sure the shipper has identified, marked and labeled the hazardous materials properly. Refuses leaking packages and shipments.
  • Placards vehicle when loading, if required.
  • Safely transports the shipment without delay.
  • Follows all special rules about transporting hazardous materials.
  • Keeps hazardous materials shipping papers and emergency response information in the proper place.
Previous Next
Question #451 (10 of 10)

Give a brief explanation of the problem:

Optional: Leave your email address if you would like a reply:

Report Cancel

The business or person to whom a shipment is delivered is called:

  • The consignee
  • The shipper
  • The carrier
  • The hauler

Consignee — The business or person to whom a shipment is delivered.

Previous Next
Complete!

Choose your next section:

Go!

About The Hazardoud Materials CDL Exam

The Hazardoud Materials written CDL Exam is required to obtain your hazardous materials endorsement on your CDL. You must have a Commercial Drivers License (CDL) with a hazardous materials endorsement before you drive any size vehicle that is used to transport hazardous material as defined in 49 CFR 383.5. You must pass a written test about the regulations and requirements to get this endorsement.

  • Bulk Tank Loading, Unloading and Marking
  • Driver Responsibilities
  • Driving and Parking Rules
  • Communications Rules
  • Emergencies
  • Loading and Unloading

Hazardous Materials Transportation - Shipper's Responsibility

The Shipper

  • Sends products from one place to another by truck, rail, vessel or airplane.
  • Provides correct placards.
  • Packages, marks and labels the materials, prepares shipping papers, provides emergency response information and supplies placards.
  • Certifies on the shipping paper that the shipment has been prepared according to the rules (unless you are pulling cargo tanks supplied by you or your employer).

The shipper also uses the hazardous materials regulations to determine the product’s:

  • Proper shipping name.
  • Hazard class.
  • Identification number.
  • Packing group.
  • Correct packaging.
  • Correct label and markings.

Carrier And Driver Responsibility

The Carrier

  • Takes the shipment from the shipper to its destination.
  • Prior to transportation, checks that the shipper correctly described, marked, labeled and otherwise prepared the shipment for transportation.
  • Refuses improper shipments.
  • Reports accidents and incidents involving hazardous materials to the proper government agency.

The Driver

  • Makes sure the shipper has identified, marked and labeled the hazardous materials properly.
  • Refuses leaking packages and shipments.
  • Placards vehicle when loading, if required.
  • Safely transports the shipment without delay.
  • Follows all special rules about transporting hazardous materials.
  • Keeps hazardous materials shipping papers and emergency response information in the proper place.

Drivers must keep hazardous materials shipping papers in one of three ways:

  • In a pouch on the driver's door
  • In clear view within immediate reach while the seat belt is fastened while driving
  • On the driver's seat when out of the vehicle

Placards

Placards are used to warn others of hazardous materials. Placards are signs put on the outside of a vehicle and on bulk packages, which identify the hazard class of the cargo.

A placarded vehicle must have at least four identical placards. They are put on the front, rear, and both sides of the vehicle. Placards must be readable from all four directions. They are at least 10 3/4 inches square, square-on-point, in a diamond shape.

Cargo tanks and other bulk packaging display the identification number of their contents on placards or orange panels or white square-on-point displays that are the same size as placards.

The Shipping Paper

The shipping paper describes a shipment. A shipping paper for hazardous materials must include:

  • Page numbers if the shipping paper has more than one page. The first page must tell the total number of pages
  • A proper shipping description for each hazardous material.
  • A shipper's certification, signed by the shipper, saying the shipment was prepared according to the regulations.

The Item Description

If a shipping paper describes both hazardous and non-hazardous products, the hazardous materials will be either:

  • Described first.
  • Highlighted in a contrasting color.
  • Identified by an "X" placed before the shipping name in a column captioned "HM.” The letters "RQ" may be used instead of "X" if a reportable quantity is present in one package.

Recognizing Hazardous Materials

Learn to recognize shipments of hazardous materials. To find out if the shipment includes hazardous materials, look at the shipping paper. Does it have:

  • An entry with a proper shipping name, hazard class and identification number?
  • A highlighted entry or one with an X or RQ in the hazardous materials column?
  • What business is the shipper in (e.g., paint dealer, chemical supply, scientific supply house, pest control or agricultural supplier, explosives, munitions or fireworks dealer).
  • Are there tanks with diamond labels or placards on the premises?
  • What type of package is being shipped? Cylinders and drums are often used for hazardous materials shipments.
  • Is a hazard class label, proper shipping name or identification number on the package?
  • Are there any handling precautions?

Placarding Rules & Regulations

Attach the appropriate placards to the vehicle before you drive it. You are only allowed to move an improperly placarded vehicle during an emergency in order to protect life or property. Placards must appear on both sides and both ends of the vehicle. Each placard must be:

  • Easily seen from the direction it faces.
  • Placed so the words or numbers are level and read from left to right.
  • At least 3 inches away from any other markings.
  • Kept clear of attachments or devices such as ladders, doors and tarpaulins.
  • Kept clean and undamaged so that the color, format and message are easily seen.
  • Be affixed to a background of contrasting color.
  • The use of “Drive Safely” and other slogans is prohibited.

The front placard may be on the front of the tractor or the front of the trailer. To decide which placards to use, you need to know:

  • The hazard class of the materials.
  • The amount of hazardous materials shipped.
  • The total weight of all classes of hazardous materials in your vehicle.

Questions You Should Know About Hazardous Materials

  • 1. Shippers package in order to (fill in the blank) the material.
  • 2. Driver placard their vehicle to (fill in the blank) the risk.
  • 3. What three things do you need to know to decide which placards (if any) you need?
  • 4. A hazardous materials identification number must appear on the (fill in the blank) and on the (fill in the blank). The identification number must also appear on cargo tanks and other bulk packaging.
  • 5. Where must you keep shipping papers describing hazardous materials?

Parking a Placarded Vehicle Not Transporting Division 1.1, 1.2 or 1.3 Explosives

You may park a placarded vehicle (not laden with explosives) within 5 feet of the traveled part of the road only if your work requires it. Do so only briefly. Someone must always watch the vehicle when parked on a public roadway or shoulder. Do not uncouple a trailer and leave it with hazardous materials on a public street. Do not park within 300 feet of an open fire.

Attending Parked Vehicles

The person attending a placarded vehicle must:

  • Be in the vehicle, awake and not in the sleeper berth or within 100 feet of the vehicle and have it within clear view.
  • Be aware of the hazards of the materials being transported.
  • Know what to do in emergencies.
  • Be able to move the vehicle, if needed.

Hazmat Route Restrictions

Some states and counties require permits to transport hazardous materials or wastes. They may limit the routes you can use. Local rules about routes and permits change often. It is your job as driver to find out if you need permits or must use special routes. Make sure you have all needed papers before starting.

If you work for a carrier, ask your dispatcher about route restrictions or permits. If you are an independent trucker and are planning a new route, check with state agencies where you plan to travel. Some localities prohibit transportation of hazardous materials through tunnels, over bridges or other roadways. Always check before you start.

Whenever placarded, avoid heavily populated areas, crowds, tunnels, narrow streets and alleys. Take other routes, even if inconvenient, unless there is no other way. Never drive a placarded vehicle near open fires unless you can safely pass without stopping.

Definitions Related To Hazmat Hauling

Bulk packaging - Packaging, other than a vessel or a barge, including a transport vehicle or freight container, in which hazardous materials are loaded with no intermediate form of containment and which has:

  • 1. A maximum capacity greater than 450 L (119 gallons) as a receptacle for a liquid;
  • 2. A maximum net mass greater than 400 kg (882 pounds) or a maximum capacity greater than 450 L (119 gallons) as a receptacle for a solid; or
  • 3. A water capacity greater than 454 kg (1000 pounds) as a receptacle for a gas as defined in Sec. 173.115

Consignee - The business or person to whom a shipment is delivered.

Division - A subdivision of a hazard class.

EPA - U.S. Environmental Protection Agency

FMCSR - The Federal Motor Carrier Safety Regulations.

Portable Tank - Bulk packaging (except a cylinder having a water capacity of 1,000 pounds or less) designed primarily to be loaded onto, or on or temporarily attached to a transport vehicle or ship and equipped with skids, mountings or accessories to facilitate handling of the tank by mechanical means. It does not include a cargo tank, tank car, multiunit tank car tank or trailer carrying 3AX, 3AAX or 3T cylinders.

Reportable Quantity - The quantity specified in Column 2 of the Appendix to Sec. 172.101 for any material identified in Column 1 of the Appendix.

Why Join Trucking Truth?

We have an awesome set of tools that will help you understand the trucking industry and prepare for a great start to your trucking career. Not only that, but everything we offer here at TruckingTruth is 100% free - no strings attached! Sign up now and get instant access to our member's section:
High Road Training Program Logo
  • The High Road Training Program
  • The High Road Article Series
  • The Friendliest Trucker's Forum Ever!
  • Email Updates When New Articles Are Posted

Apply For Paid CDL Training Through TruckingTruth

Did you know you can fill out one quick form here on TruckingTruth and apply to several companies at once for paid CDL training? Seriously! The application only takes one minute. You will speak with recruiters today. There is no obligation whatsoever. Learn more and apply here:

Apply For Paid CDL Training